卡特故障代码
故障码Component failure故障部件车辆1挖掘机维修,挖掘机修理,维修挖掘机,修理挖掘机
112 Accelerator Pedal 1 Failure加速踏板1故障
113 Accelerator Pedal /Brake Plausibility加速踏板与制动踏板信号不可信
116 Main Clutch Signal Failure离合信号故障
117 Brake Signal Failure制动踏板故障
119 Terminal 15 Failure 15 端子故障
11C Water in Fuel燃油滤清器储水器
211 Vehicle Speed Sensor Failure车速传感器故障
215 Cruise Control Buttons Irreversible巡航控制按扭不可逆故障
315 Cruise Control Buttons Reversible Failure巡航控制开关可逆故障车辆2(继电器/执行器)
125 Main Relay 2 Failure主继电器2失效
126 Battery Voltage Failure蓄电池电压故障
127 Engine Brake decompression Valve failure发动机制动失效
128 Main Relay 1-Short Circuit To Battery主继电器1与电池短路
129 Main Relay 3 Failure主继电器3故障
12A Thermostarter Relay 1(Heater)发动机制动(主继电器4)故障
12B Air Heater 1 Power Stage Failure空气加热器1 Power Stage 故障
12E Pre-Post Heating Control System (Active)预加热控制系统故障
225 Main Relay failure (Interrupted Afterrun)主继电器失效(停机后中断)
228 Main Relay 1 (High Pressure Pump) Short to Ground主继电器1对地短路发动机1(温度和压力传感器)
131 Coolant Temperature Sensor failure冷却液温度传感器
132 Coolant Temperature Dynamic failure冷却液温度传感器动态故障
133 Boost Air Temperature Sensor failure进气温度传感器
134 Boost Pressure Sensor failure进气压力传感器
135 Fuel Temperature Sensor failure燃油温度传感器
136 Rail Pressure Sensor failure共轨压力传感器
137 Common Rail Pressure Limiting Valve failure共轨压力限压阀
138 Oil Pressure Sensor failure机油压力传感器
13A Oil Temperature Sensor failure机油温度传感器
232 Coolant Temperature Test failure冷却液温度(监测)
236 Rail Pressure Sensor Offset Monitoring共轨压力传感器偏差监测
238 Oil Pressure too low机油压力过低
23A Oil Temperature too high机油温度过高发动机2(转速传感器/执行器)
141 Crankshaft Speed Signal failure曲轴转速传感器
142 Engine runs with Camshaft Speed only只有凸轮轴传感器信号
143 Camshaft Speed Signal failure凸轮轴传感器
144 Offset between Camshaft and Crankshaft凸轮轴传感器和曲轴传感器信号偏差超出限值
149 Filter Heater failure燃油滤芯加热器故障
14A Engine Compartment Start Button stuck发动机机舱启动按钮发卡
14D Info: Engine Overspeed Protection提示:发动机超速保护
24A Engine Compartment Stop Button stuck发动机机舱停止按钮发卡共轨系统燃油计量
152 Rail Pressure Positive Deviation High and High Fuel Flow Setpoint Value共轨压力正偏差过高和燃油流量设定值过高
153 Rail Pressure Negative Deviation too High on Minimum Metering共轨压力负偏差过高(小流量)
154 Rail Pressure below Minimum Limit in Controlled Mode共轨压力低于小极限
155 Rail Pressure above Maximum Limit in Controlled Mode共轨压力大于大极限
156 Rail Pressure Drop Rate too High共轨燃油压力下降率太高
157 Setpoint of Rail Metering Unit not plausible in Overrun超速时共轨计量阀不真实
158 Fuel Flow Setpoint of Common Rail Metering Unit too low共轨计量装置燃油流量设置点过低
159 Common Rail Metering Unit Power Stage failure共轨油泵计量阀Power Stage 故障
259 Common Rail Metering Unit Power Stage Short to Battery共轨计量阀正极短路
359 Common Rail Metering Unit Power Stage Short to Ground共轨计量阀负极短路喷油器1挖掘机技术故障请与师傅进行沟通交流，官方网站修理直拨:0551-64493367技术,电话/微信:13956953738
